Skip to main content
  • Research article
  • Open access
  • Published:

Heterologous expression of Aspergillus aculeatus endo-polygalacturonase in Pichia pastoris by high cell density fermentation and its application in textile scouring

Abstract

Background

Removal of non-cellulosic impurities from cotton fabric, known as scouring, by conventional alkaline treatment causes environmental problems and reduces physical strength of fabrics. In this study, an endo-polygalacturonase (EndoPG) from Aspergillus aculeatus produced in Pichia pastoris was evaluated for its efficiency as a bioscouring agent while most current bioscouring process has been performed using crude pectinase preparation.

Results

The recombinant EndoPG exhibited a specific activity of 1892.08 U/mg on citrus pectin under the optimal condition at 50 °C, pH 5.0 with a V max and K m of 65,451.35 μmol/min/mL and 15.14 mg/mL, respectively. A maximal activity of 2408.70 ± 26.50 U/mL in the culture supernatant was obtained by high cell density batch fermentation, equivalent to a 4.8 times greater yield than that from shake-flask culture. The recombinant enzyme was shown to be suitable for application as a bioscouring agent, in which the wettability of cotton fabric was increased by treatment with enzyme at 300 U/mL scouring solution at 40 °C, pH 5.0 for 1 h. The bio-scoured fabric has comparable wettability to that obtained by conventional chemical scouring, but has higher tensile strength.

Conclusion

The work has demonstrated for the first time functions of A. aculeatus EndoPG on bioscouring in eco-textile processing. EndoPG alone was shown to possess effective scouring activity. High expression level and homogeneity could be achieved in bench-scale bioreactor.

Background

Cotton is an important natural resource used in the textile industry. It is a highly pure natural cellulosic material, comprising approximately 90% cellulose that is organized into strong microfiber structures. Pectin is a major non-cellulosic impurity present in the cuticle and primary cell wall of cotton. It acts as a cementing material for the cellulosic network and as a hydrating agent that controls the movement of water and plant fluids [1], providing firmness and rigidity to the cotton fibers. The backbone of pectin is made of α-1,4-linked D-galacturonic acid residues, in which the carboxylic groups of galacturonic acid are largely esterified with methoxy groups, while the hydroxyl groups on the backbone can be partially acetylated. Xylose, galactose and arabinose are present as side chain sugars of pectin [2]. The hydrophobic nature of pectin is responsible for the non-wetting behavior of the native cotton, which creates difficulty for fabric dyeing in textile processing [3].

Conventionally, pectin and other waxy substances in cotton fabrics are removed by boiling alkali treatment in a process known as scouring. This process makes the fabric more hydrophilic and more accessible for subsequent textile processing. The scouring process carries an environmental burden owing to the large consumption of sodium hydroxide and water (the latter is required for an intensive rinsing step). In addition, scouring also causes non-specific degradation of cellulose, which decreases the tensile strength of fibers, and consequently leads to lower fabric quality [4]. In contrast to the harsh conditions employed in the conventional scouring process, enzymatic processing (bioscouring) can be performed under mild reaction conditions using individual or combinations of different enzymes including lipases, proteases, cellulases and pectinases [15]. Among them, pectinases are the most promising [6]. Pectinases release waxes and other non-cellulosic components of the cotton fibers with minimal non-specific damage to the cellulosic structure. Pectinase penetrates the cuticle layer of cotton fiber through cracks or micropores and then partially breaks down pectin in the primary wall matrix [1, 5]. The breakdown of pectin loosens linkages between the cuticle and the cellulose body leading to increased absorbency of the fabric.

According to the mode of action and substrate preference, pectinases are classified into two groups, namely (i) pectin esterases (EC 3.1.1.11) and (ii) pectin depolymerases, which are further divided into polygalacturonases (EC 3.2.1.15, EC 3.2.1.67 and EC 3.2.1.82) and lyases (EC 4.2.2.2 and EC 4.2.2.10) [5]. Polygalacturonases usually work optimally under an acidic range and require no co-factors for their catalysis. Conversely, lyases require divalent metal co-factors and are optimally active under alkaline conditions [7]. Crude pectinase preparations isolated from fungi, for example Aspergillus spp. and Penicillium spp. that have been tested for potential as bioscouring agents of cotton textiles, possess strong pectate lyase activity. This enzyme works optimally under alkaline conditions, which is compatible with the production of peroxide in the subsequent bleaching step [8, 9] while there has been no report on application of purified or recombinant pectate lyases or polygalacturonases in bio-scouring. In addition to bioscouring, enzymatic starch removal (desizing) using amylases prior to the bioscouring step has been shown to have potential for reducing operating time and energy consumption in textile processing [5, 10]. Combined desizing and bioscouring treatment using amylases and pectinases is hindered by the very different optimal pH of these enzymes. Searching for acidic pectinase working on bioscouring under acidic conditions optimal is thus challenging.

In this study, we aimed to express a recombinant acidic endo-polygalacturonase from A. aculeatus in methylotrophic yeast P. pastoris using high cell density fermentation. The recombinant enzyme was evaluated in eco-friendly textile processing in comparison to the conventional alkaline scouring process. The developed biscouring process has demonstrated for the first time the action of polygalacturonase on textile scouring with advantages on improved physical properties of the fabrics and allows further optimization of the one-step desizing-scouring for textile processing.

Methods

Strains, culturing conditions, genes, and primers

The endo-polygalacturonase gene (endoPG), encoding the mature endo-polygalacturonase (EndoPG) without a signal peptide was synthesized based on the coding sequence of A. aculeatus ATCC16872. The codon usage was analyzed by Codon Usage Analyzer [11] and optimized for expression in P. pastoris using Gene Designer Software [12]. The optimized gene was synthesized by Genescript (Piscataway, NJ, USA). Escherichia coli DH5α was used as a host for plasmid propagation. E. coli was propagated in low salt Luria-Bertani (LB) medium (1% (w/v) tryptone, 0.5% (w/v) NaCl, and 0.5% (w/v) yeast extract) at 37 °C. P. pastoris KM71 (Invitrogen, Carlsbad, CA, USA) was used as a host for EndoPG expression and was cultured in YPD (1% (w/v) yeast extract, 2% (w/v) peptone, and 2% (w/v) glucose). P. pastoris transformants were selected on YPD agar containing 100 μg/mL Zeocin (Invitrogen, Carlsbad, CA, USA). pPICZαA vector (Invitrogen) was used as the expression vector. All synthetic oligonucleotides used in this study were purchased from 1st Base (Selangor, Malaysia).

Construction of expression plasmids

The expression plasmid carrying endoPG gene was constructed by amplification of the endoPG in pUC57-EndoPG plasmid with a primer pair, EndoPG-F21 (GCATGAATTCGCACCTACAGACATCGAGAAGAGATC; EcoRI site underlined) and EndoPG-R1 (TACATCTAGATTAGCAACTGGCACCGGAAG; XbaI underlined) for the native mature enzyme. The amplicon was digested with EcoRI and XbaI and ligated with pPICZαA-digested vector. The recombinant pPICZαA containing endoPG (designated as pPIC-PG1), was transformed into E. coli DH5α by the heat shock method according to Sambrook and Russel [13]. Transformants were cultivated and selected on LB plates supplemented with 25 μg/mL Zeocin. The DNA sequences of the recombinant plasmids were verified by Sanger sequencing (1st Base, Selangor, Malaysia).

Heterologous expression of EndoPG in P. pastoris KM71

The plasmid pPIC-PG1 was linearized with PmeI (Thermo Scientific, Waltham, MA, USA) and then transformed into P. pastoris KM71 by electroporation (Gene Pulser, Bio-Rad, Hercules, CA, USA) according to the Easy Select™ Pichia Expression Kit instructions (Invitrogen, Carlsbad, CA, USA). Sixty colonies of putative recombinant clones were randomly selected from YPDS plates (1% (w/v) yeast extract, 2% (w/v) peptone, 2% (w/v) glucose, 18.2% (w/v) sorbitol, and 1.5% (w/v) bacto agar) supplemented with 100 μg/mL Zeocin. Integration of the gene into the P. pastoris genome was confirmed by colony PCR using 5′AOX1-F (5′-GACTGGTCCAATTGACAAGC-3′) and 3′AOX1-R (5′-CGAAATGGCATTCTGACATGG-3′) primers according to Easy Select™ Pichia Expression Kit instructions (Invitrogen, Carlsbad, CA, USA).

Five mL of YPD medium was inoculated with a single colony of P. pastoris transformant and incubated at 30 °C for overnight with rotary shaking at 250 rpm until the OD600 reached 5–6. One milliliter of the seed culture was transferred to 25 mL of the buffered glycerol-complex medium (BMGY; 1% (w/v) yeast extract, 2% (w/v) peptone, 100 mM potassium phosphate buffer pH 6.0, 1.34% (w/v) YNB, 0.0004% (w/v) biotin, and 1% (v/v) glycerol) and the culture was grown under the same condition as described above for 24 h. The cell pellet was then harvested and resuspended in one-fifth of the original culture volume with methanol-minimal medium (BMMY; 1% (w/v) yeast extract, 2% (w/v) peptone, 100 mM potassium phosphate buffer pH 6.0, 1.34% (w/v) YNB, 0.0004% (w/v) biotin, and 3.0% (v/v) methanol). Absolute methanol was added to a final concentration of 3% (v/v) to induce expression of the heterologous gene. The cell-free supernatant was collected at 1, 2, 3, and 4 days after induction for monitoring protein expression by SDS-PAGE [13]. To remove residual culture media and contaminants, the enzyme used for biochemical characterization was further processed by using ultrafiltration (Amicon® Ultra-15, Millipore) with 50 mM potassium phosphate buffer pH 6. Protein concentration was analyzed with Bio-Rad Protein Assay Reagent based on Bradford’s method (Bio-Rad, Hercules, CA, USA) using bovine serum albumin as the standard [14].

Enzyme activity assay

Pectinase activity was assayed based on hydrolysis of pectin. 0.34 mL assay reactions contained an appropriate enzyme dilution in 0.5% citrus pectin (w/v) in 100 mM sodium acetate buffer and incubated at 50 °C for 10 min. The amount of liberated reducing sugars was determined by the dinitrosalicylic acid (DNS) method using D-(+)-galacturonic acid as a standard [15]. The amylase, Avicelase, and CMCase activities were analyzed using 1% soluble starch, 1% microcrystalline cellulose (Avicel®) and 1% carboxymethylcellulose as the substrates, respectively, according to the reaction conditions described above using glucose as the standard. One unit of enzyme activity was defined as the amount of enzyme that catalyzes the formation of 1 μmol of reducing sugar from substrate per min under its optimal conditions. The experiments were done in triplicate.

Characterization of recombinant EndoPG

The effects of pH on activity of EndoPG was determined at 50 °C for 10 min with a pH range from 2.0 to 9.0, using 100 mM citric acid-sodium citrate (pH 2.0-4.0), 100 mM acetic acid-sodium acetate (pH 4.0-6.0), 100 mM potassium phosphate (pH 6.0-8.0), and 100 mM Tris-Cl (pH 8-9). The optimum temperature was determined within the temperature range of 30–80 °C at pH 5 in 100 mM sodium acetate buffer. The pH stability of the enzyme was studied by incubation of the enzyme at 4 °C in buffers with varying pH for 24 h before determination of the residual pectinase activity under the standard conditions (50 °C, pH 5.0). Thermostability was determined by pre-incubating the enzymes in 100 mM acetate buffer, pH 5.0 at different temperatures (20–60 °C) for varying time intervals from 0.5 to 3 h before analyzing the residual pectinase activity relative to the enzyme activity without pre-incubation denoted as 100%.

The effect of salts (NaCl and KCl), divalent metal ions (CaCl2, CuSO4, MgCl2, MnSO4, ZnSO4, FeSO4, and CoCl2) and divalent ion chelator (EDTA) on the enzyme activity was studied by pre-incubating an appropriate dilution of the enzyme in the presence of the compounds at 1 mM at 0 °C for 30 min before determining the pectinase activity under the standard assay conditions. The enzyme activity in the absence of supplemented chemicals was considered as 100%. The data were analyzed by Dunnett’s multiple comparison test compared to the control.

The specificity of EndoPG was assayed on polygalacturonic acid with varying degrees of esterification. The assay reactions contained an appropriate enzyme dilution with 0.5% w/v of non-esterified polygalacturonic acid, [6.7%]- or [55–70%]-esterified-pectin from citrus peel (Sigma-Aldrich, USA) in 100 mM sodium acetate buffer, pH 5 and incubated at 50 °C for 10 min. The amount of released reducing sugars was determined using the DNS method as described above. The substrate specificity was expressed as relative percent activity compared with the activity on polygalacturonic acid.

Esterified pectin (6.7%) was used as substrate for the kinetic studies. The K m and V max were determined at different substrate concentrations ranging from 0.2 to 20 mg/mL under standard assay conditions (50 °C with an incubation time of 5 min). The kinetics data were calculated and defined by the SigmaPlot 7 (Systat Software, San Jose, CA).

High cell density fermentation

The recombinant P. pastoris expressing EndoPG was cultivated in high cell density fed-batch fermentation in a 5-L bioreactor (B. Braun Sartorius Ltd., Göttingen, Germany) with the method modified from Charoenrat et al. (2013) [16]. Briefly, the primary inoculum was prepared by inoculating a colony of the recombinant P. pastoris into a 125 mL flask containing 20 mL of YPD broth and incubated at 30 °C with rotary shaking at 250 rpm for 24 h before subcultivating 20 mL of the inoculum into 180 mL FM22 medium. The FM22 medium contained: KH2PO4, 42.9 g/L; CaSO4, 0.93 g/L; K2SO4, 14.3 g/L; MgSO4 · 7H2O, 11.7 g/L; (NH4)2SO4, 5.0 g/L; glycerol, 20.0 g/L; histidine, 2.0 g/L and PTM1, 4.35 mL/L. The trace salt (PTM1) contained: CuSO4 · 5H2O, 6.0 g/L; KI, 0.08 g/L; MnSO4 · H2O, 3.0 g/L; Na2MoO4 · 2H2O, 0.2 g/L; H3BO3, 0.02 g/L; ZnCl2, 20.0 g/L; FeCl3, 13.7 g/L; CoCl2 · 6H2O, 0.9 g/L; H2SO4, 5.0 mL/L; and biotin, 0.2 g/L. The culture was further incubated at 30 °C with rotary shaking at 250 rpm for 48 h. A 5-L bioreactor vessel containing 1.8 L basal salt medium (2.67% (v/v) phosphoric acid 85%, 0.093% (w/v) CaSO4, 1.82% (w/v K2SO4, 1.49% (w/v) MgSO4.7H2O, 0.413% (w/v) KOH, 4% (w/v) glycerol) was inoculated with 200 mL of the secondary inoculum. The fermentation parameters were controlled at 30 °C, 500–700 rpm agitation, 30% dissolved oxygen (DO), with 1 vvm aeration, and pH 5.0, adjusted using NH4OH. The fed-batch cultivation was divided into four stages: glycerol batch stage, glycerol fed-batch stage, methanol induction stage, and production stage as described previously by Jahic et al. [17]. The batch culture was grown until the glycerol was exhausted and the fed-batch mode was applied by constant glycerol feeding at 18.15 mL/h/L of initial fermentation volume for 4 h. The methanol induction feed was started after 3–5 h to avoid repression of AOX promoter [18]. Then, 100% methanol feed was added continuously into the fermentation culture, starting at a rate of 1.00 mL/h/L fermentation volume for the first 2 h and gradually increasing by 10% increments every 1 h to a target rate of 3.00 mL/h/L fermentation volume, which was maintained during the fermentation process. The pectinase activity, dry-cell weight, and protein concentration of the fermenter culture were monitored throughout the cultivation.

Enzymatic scouring of cotton fabrics

A 211 g/m2 enzymatically desized plain-woven 100% cotton fabric (PYI) (Thanapaisal R.O.P, Samutprakarn, Thailand) with a weight of 3.0 g was placed in a 500 mL container with different concentrations of EndoPG (100, 200, 300 and 400 U/mL) at a liquor to fabric ratio of 20:1 in the presence of 0.2% (w/v) wetting agent (Hostapal® NIN liq c, Archroma, Singapore). The enzymatic scouring process was carried out in a DaeLim Starlet II DLS-8080 infrared lab dyeing machine at 40 °C for 1 h in 50 mM sodium acetate buffer, pH 5.0 with a heating rate of 2 °C/min and a shaking rate of 30 rpm. The enzyme was inactivated by boiling in distilled water for 10 min twice. The fabric samples were washed twice with distilled water at room temperature and then air-dried. A control treatment was carried out without enzyme addition. Conventional chemical scouring was performed in a 0.2 NaOH solution at 100 °C for 30 min [9]. All experiments were performed in triplicate.

The fabric weight loss was expressed as a percentage loss in weight of fabric after drying at 80 °C in an air-circulated oven water bath with respect to the initial dry weight of the fabric. The samples were weighed after cooling in a desiccator. Water absorbency was evaluated according to the AATCC test method 79-1995 [19]. Tensile strength test was performed according to the ASTM 5034-09 protocol using a bench top material testing machine (H5K-T UTM, Tinius Olsen, PA, USA) with a 75 mm gauge length at an extension rate of 300 mm/min. Three experiments in warp and weft directions were carried out for each sample.

Results

Expression of A. aculeatus EndoPG

In this study, mature A. aculeatus EndoPG was expressed in P. pastoris KM71 in a secreted form. The endoPG gene (1029 bp) was fused in frame to the α–factor secretion signal, under the control of the AOX1 promoter. Induction with methanol led to strong expression of EndoPG in the culture supernatant with high homogeneity (>90%) as shown by SDS-PAGE (Fig. 1). The apparent size of the secreted protein was concordant with the theoretical MW of 38.7 kDa. The highest enzyme expression was obtained after 48 h induction by methanol with the maximal polygalacturonase activity in the shake-flask culture of 503 ± 3 U/mL and a specific activity of 1892 U/mg.

Fig. 1
figure 1

SDS-PAGE analysis of the culture supernatant containing secreted recombinant EndoPG. Lanes M: unstained protein molecular weight markers (Thermo Scientific, Illinois, USA). Lane 1 and 2: culture supernatant of control P. pastoris containing pPICZαA and the recombinant clone expressing EndoPG, respectively, after 48 h of methanol induction. The migration of protein band corresponding to the recombinant EndoPG (38.7 kDa) is marked by an arrow

Biochemical characterization and kinetic study of EndoPG

Effects of pH and temperature on the EndoPG activity and stability were studied in order to determine the enzyme’s optimal working conditions (Additional file 1). The recombinant enzyme demonstrated optimal pH and temperature of 5.0 (Fig. 2a) and 50 °C (Fig. 2b), respectively. It retained more than 60% of its initial activity after incubation at 40 °C for 180 min (Fig. 3a). However, the enzyme rapidly lost activity at 50 °C and 60 °C. The pH stability test showed that more than 80% of enzyme activity was retained after incubation in pH 2.0 to 6.0 for 24 h (Fig. 3b). A marked decrease in enzyme activity was observed at pH 7.0 to 9.0.

Fig. 2
figure 2

Effects of (a) pH and (b) temperature on EndoPG activity. The highest activity under the optimal condition (in sodium acetate buffer pH 5 at 50 °C) was considered as 100% relative activity. Data points are the mean values and error bars represent standard deviations from triplicate experiments

Fig. 3
figure 3

Effects of temperature (part a) and pH (part b) on stability of EndoPG. Thermostability was determined by incubating the enzyme at different temperatures (20–60 °C) in 100 mM sodium acetate buffer, pH 5 and measuring the residual activity under the optimal enzyme working conditions. For pH stability, the enzyme was incubated at various pH buffers 2.0–9.0 at 50 °C and the residual activity was measured after 24 h. The activity without pre-incubation was denoted as 100%. Data points are the mean values and error bars represent standard deviations from triplicate experiments

The effects of metal ions and divalent ion chelator on the activity of EndoPG were examined by determining the enzyme activity in the presence of the additives. Among the various additives tested, Cu2+ and Fe2+ stimulated the activity of EndoPG (p < 0.05) (Table 1). In contrast, Mn2+, Na+ and Zn2+ inhibited the enzyme. K+, Li+, Mg2+ and the divalent ion chelator (EDTA) was found to have no significant effect on the enzyme activity.

Table 1 Effects of additives (metal ions and chelator) on the activity of EndoPG

The recombinant EndoPG showed the highest activity on polygalacturonic acid, followed by pectin with different degrees of esterification with the relative activity 22–25% of that obtained on the non-esterified substrate (Table 2). There was no non-specific hydrolysis activity against starch or cellulose. The estimated enzyme kinetic parameters of EndoPG for pectin digestion were K m of 15.14 mg/mL and V max of 65,451.35 μmol/min/mL.

Table 2 Substrate specificity of EndoPG

High cell-density fermentation

Production of EndoPG was further studied using high cell-density fermentation approach in a laboratory-scale fermenter. The fed-batch fermentation process comprised three steps including glycerol batch, transition or glycerol fed-batch, and methanol induction or production phases (Fig. 4). The inoculum was prepared in synthetic FM22 medium in order to increase cell density and enzyme production. The glycerol batch stage was carried out for the first 30 h. At the end of glycerol batch stage, the dry cell weight reached 23 g/L. Subsequently, the glycerol fed-batch stage was initiated using constant feeding at the rate of 18.15 mL/h/L of the initial fermentation volume for 4 h. During the glycerol fed-batch stage, the cell dry-weight increased almost two fold from 23 to 41 gCDW/L. The EndoPG activity reached the highest level of 2408.00 U/mL in the induction stage (111 h) with the specific production yield of 43,781.81 U/g biomass. The high cell density fermenter thus resulted in 4.8 times greater enzyme production yield compared with the shake-flask culture.

Fig. 4
figure 4

High density fermentation profile of EndoPG production in P. pastoris. The cultivation condition during the production stage was maintained at 30 °C and pH 5.0

Bioscouring by EndoPG

The performance of EndoPG on bioscouring of cotton fabric was tested based on weight loss and wettability assay (Table 3). Enzymatic treatment of the fabric with EndoPG led to a marked improvement on water absorbency of the fabric samples compared with the control of no enzyme treatment. The control fabric showed low water absorbency with a wettability time greater than 3 min. Increasing enzyme dosage led to increased fabric wettability (shorter wettability time) and corresponding increased weight loss of fabric. Maximum water absorbency of 16.5 s was observed at the highest enzyme dosage, which was comparable to that measured for fabric scoured by alkali treatment; however, with a lower weight loss of the textile. In addition, the fabrics treated with EndoPG showed a greater tensile strength for both the weft yarn (722.33 N) and warp yarn (986.67 N) compared with that obtained using chemical scouring (Table 4). The results clearly indicated potential and advantages of the bioscouring process using EndoPG as a promising alternative to the conventional alkaline scouring method. Similar results on weight loss, wettability and tensile compared to those obtained using buffer alone were observed using the heat-inactivated enzyme (data not shown).

Table 3 Comparison of weight loss and wettability of the fabrics scoured by enzyme (EndoPG) and alkali treatment (sodium hydroxide)
Table 4 Comparison of tensile strength between fabrics scoured by enzyme (EndoPG) and alkali treatment (sodium hydroxide)

Discussion

Heterologous expression of composite enzymes attacking pectin including polygalacturonases, pectate lyases, and pectin esterases from various ascomycetes and basidiomycetes fungi has been reported in yeasts [2024]. P. pastoris is considered an efficient expression system owning to its high production yield of heterologous proteins in secreted forms, allowing cost competitive enzyme production with minimal downstream processing [17, 18]. Recombinant endo-polygalacturonases from A. niger, Bispora sp., Phytophthora parasitica and Penicillium sp. produced in P. pastoris expression system have been reported with varying biochemical characteristics [2023]. A. aculeatus is a promising producer of multi-component starch and cell wall degrading enzymes with potent application in various biotechnological processes [25, 26]. In this study, an EndoPG from A. aculeatus ATCC16872 was expressed as a major protein in the culture supernatant with >90% homogeneity, allowing production of the enzyme with no need for subsequent downstream purification. The enzyme showed a specific activity of 1892 U/mg total protein (50 °C, pH 5) which is comparable to the equivalent recombinant enzyme from A. niger [20]. The optimal activity of the enzyme at 50 °C was relatively higher than that of the commercial acid fungal polygalacturonase, which works optimally at 40 °C [9].

Production of EndoPG by high cell density fermentation was achieved yielding maximal activity of 2408 U/mL. The greater yield of enzyme from fermentation compared with batch cultivation is due to the higher cell density achievable in the former, as shown by OD600 of 81.60, equivalent to a cell concentration of 40.83 g/L at the exponential glycerol feeding stage before induction by methanol. The benefit of improved yield of enzyme using high cell density fermentation has also been reported for other types of recombinant enzymes expressed in P. pastoris e.g., xylanase and cellulase [18, 27]. To our knowledge, our work represents the first report on heterologous expression and high cell density fermentation of polygalacturonase in P. pastoris with the highest production yield, 43,781.81 U/g biomass, resulting in the higher enzyme productivity compared to that obtained using batch cultivation using wild type or recombinant microorganisms [2226].

Bioscouring of cotton fabrics using pectinases has been shown as an interesting approach for reducing chemical and energy consumption in textile processing. Compared to conventional chemical scouring using alkalis such as sodium hydroxide and soaps at high temperature, the bioscouring alternative can result in complete replacement of the scouring chemicals and as the enzymatic process is performed under lower temperature, which leads to substantial saving of cost for energy and waste water treatment [5, 9, 28]. Although EndoPG showed the optimal temperature at 50 °C, the bioscouring process was carried out at 40 °C at which the enzyme showed high catalytic activity with high operational stability (>80% of its maximal activity was retained after 60 min). The lower operating temperature in the scouring step also has advantage on a lower energy cost. Crude pectinases from various bacterial and fungal origins have been used for bioscouring of cottons and other types of textiles e.g., linen and ramie [2]. The use of purified or recombinant composite pectinases on bioscouring has not been previously reported. The recombinant pectinase reported here was shown to be capable of enzymatic bioscouring with a maximal water adsorbancy of 16.5 s, which is in the accepted range for industrial processing (<30 s). However, application of either crude enzymes rich in polygalacturonase or pectate lyase activity alone has been reported to show incomplete scouring on the fabric in some cases [9, 29, 30]. Pectate lyases catalyze trans-elimination of a-1,4-glycosidic linkage in pectic acid and form products with 4,5-unsaturated residues at the non-reducing end. These structural changes increase more polar functional groups and hence the hydrophilicity on the surface of cotton fibers, which could be an important factor for the improved water absorption and dyeability of the treated fabrics. The results thus suggest further formulation of the EndoPG with pectate lyases or other composite pectinolytic enzymes as well as other enzymes e.g., cellulases and cutinases [6, 31] to improve its performance. The EndoPG catalyzed process resulted in fabrics with higher tensile strength compared with the chemical scouring method. This reflected the higher specificity of the enzyme on attacking the polygalacturonic acid backbone of pectin with no decomposition of the cellulose fibers, which is an undesirable side activity of alkali in chemical scouring [9, 28]. This resulted in fabrics with higher strength with lower weight loss from the enzymatic process.

Conclusion

The applicability of a recombinant cellulase-free polygalacturonase (A. aculeatus EndoPG) on bioscouring has been demonstrated. The enzyme can be produced efficiently by high-cell density fermentation in the P. pastoris system and showed its potential on completely replacing the use of toxic scouring chemical with substantial energy saving. The EndoPG characterized in this study represents a promising alternative for efficient bioscouring towards establishment of an eco-friendly textile processing industry.

Abbreviations

AOX:

Alcohol oxidase

CDW:

Cell dry weight

EndoPG:

Endo-polygalacturonase

References

  1. Li Y, Hardin IR. Enzymatic scouring of cotton-surfactants, agitation and selection of enzymes. Text Chem Color. 1998;30:23–9.

    CAS  Google Scholar 

  2. Kashyap DR, Vohra PK, Chopra S, Tewari R. Applications of pectinases in the commercial sector: a review. Bioresour Technol. 2001;77:215–27.

    Article  CAS  Google Scholar 

  3. Lin CH, Hsieh YL. Direct scouring of greige cotton fabrics with proteases. Text Res J. 2001;71:425–34.

    Article  CAS  Google Scholar 

  4. Buschle-Diller G, El Mohgahz Y, Inglesby MK, Zeronian SH. Effects of scouring with enzymes, organic solvents, and caustic soda on the properties of hydrogen peroxide bleached cotton yarn. Text Res J. 1998;68:920–9.

    Article  CAS  Google Scholar 

  5. Etters JN. Cotton preparation with alkaline pectinase: an environmental advance. Text Chem Color Am D. 1999;1:33–6.

    CAS  Google Scholar 

  6. Karapinar E, Sariisik MO. Scouring of cotton with cellulases, pectinases and proteases. Fibres Text East Eur. 2004;12:79–82.

    CAS  Google Scholar 

  7. Collmer A, Reid J, Mount M. Assay methods for pectic enzymes. Method Enzymol. 1988;161:329–35.

    Article  CAS  Google Scholar 

  8. Miller CA, Jorgensen SS, Otto EW, Lange MK, Condon B, J L. Alkaline enzyme scouring of cotton textiles. US Patent. US 5,912,407.

  9. Tzanov T, Calafell M, Guebitz GM, Cavaco-Paulo A. Bio-preparation of cotton fabrics. Enzyme Microb Tech. 2001;29:357–62.

    Article  CAS  Google Scholar 

  10. Nimchua T, Rattanaphan N, Champreda V, Pinmanee P, Kittikhun S, Eurwilaichitr L, et al. One-step process for desizing and scouring of cotton fabric by multienzyme. Thai Patent 2012. TH 1203000885.

  11. Fuhrmann M, Hausherr A, Ferbitz L, Schödl T, Heitzer M, Hegemann P. Monitoring dynamic expression of nuclear genes in Chlamydomonas reinhardtii by using a synthetic luciferase reporter gene. Plant Mol Biol. 2004;55:869–81.

    Article  CAS  Google Scholar 

  12. Villalobos A. Gene designer: a synthetic biology tool for constructing artificial DNA segments. BMC Bioinformatics. 2006;7:285.

    Article  Google Scholar 

  13. Sambrook J, Russel D. Molecular cloning: A laboratory manual. 3rd ed. New York: Cold Spring Harbor Laboratory Press; 2007. p. 1.116–8.

    Google Scholar 

  14. Bradford MM. A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Anal Biochem. 1976;72:248–54.

    Article  CAS  Google Scholar 

  15. Miller GL. Use of dinitrosalicylic acid reagent for determination of reducing sugars. Anal Chem. 1959;31:426–8.

    Article  CAS  Google Scholar 

  16. Charoenrat T, Khumruaengsri N, Promdonkoy P, Rattanaphan N, Eurwilaichitr L, Tanapongpipat S, et al. Improvement of recombinant endoglucanase produced in Pichia pastoris KM71 through the use of synthetic medium for inoculum and pH control of proteolysis. J Biosci Bioeng. 2013;116:193–8.

    Article  CAS  Google Scholar 

  17. Jahic M, Rotticci-Mulder J, Martinelle M, Hult K, Enfors SO. Modeling of growth and energy metabolism of Pichia pastoris producing a fusion protein. Bioprocess Biosyst Eng. 2002;24:385–93.

    Article  CAS  Google Scholar 

  18. Ruanglek V, Sriprang R, Ratanaphan N, Tirawongsaroj P, Chantasigh D, Tanapongpipat S, et al. Cloning, expression, characterization, and high cell-density production of recombinant endo-1,4-β-xylanase from Aspergillus niger in Pichia pastoris. Enzyme Microbial Tech. 2007;41:19–25.

    Article  CAS  Google Scholar 

  19. AATCC test Method 79: Absorbency of Bleached Textiles. AATCC Technical Manual. American Association of Textile Chemists and Colorists; 1995.

  20. Liu MQ, Dai XJ, Bai LF, Xu X. Cloning, expression of Aspergillus niger JL-15 endo-polygalacturonase A gene in Pichia pastoris and oligo-galacturonates production. Protein Expres Purif. 2014;94:53–9.

    Article  CAS  Google Scholar 

  21. Yang J, Luo H, Li J, Wang K, Cheng H, Bai Y, et al. Cloning, expression and characterization of an acidic endo-polygalacturonase from Bispora sp. MEY-1 and its potential application in juice clarification. Process Biochem. 2011;46:272–7.

    Article  Google Scholar 

  22. Yan HZ, Liou RF. Cloning and analysis of pppg1, an inducible endo-polygalacturonase gene from the oomycete plant pathogen Phytophthora parasitica. Fungal Genet Biol. 2005;42:339–50.

    Article  CAS  Google Scholar 

  23. Yuan P, Meng K, Huang H, Shi P, Luo H, Yang P, et al. A novel acidic and low-temperature-active endo-polygalacturonase from Penicillium sp. CGMCC 1669 with potential for application in apple juice clarification. Food Chem. 2011;129:1369–75.

    Article  CAS  Google Scholar 

  24. Zhou H, Li X, Guo M, Xu Q, Cao Y, Qiao D, et al. Secretory expression and characterization of an acidic endo-polygalacturonase gene from Aspergillus niger SC323 in Saccharomyces cerevisiae. J Microbiol Biotechnol. 2015;25:999–1006.

    Article  CAS  Google Scholar 

  25. Rattanachomsri U, Tanapongpipat S, Eurwilaichitr L, Champreda V. Simultaneous non-thermal saccharification of cassava pulp by multi-enzyme activity and ethanol fermentation by Candida tropicalis. J Biosci Bioeng. 2009;107:488–93.

    Article  CAS  Google Scholar 

  26. Poonsrisawat A, Wanlapatit S, Paemanee A, Eurwilaichitr L, Piyachomkwan K, Champreda V. Viscosity reduction of cassava for very high gravity ethanol fermentation using cell wall degrading enzymes from Aspergillus aculeatus. Process Biochem. 2014;49:1950–7.

    Article  CAS  Google Scholar 

  27. Thongekkaew J, Ikeda H, Masaki K, Iefujii H. An acidic and thermostable carboxymethyl cellulase from yeast Cryptococcus sp. S-2: purification, characterization and improvement of its recombinant enzyme production by high cell-density fermentation of Pichia pastoris. Protein Expres Purif. 2008;60:140–6.

    Article  CAS  Google Scholar 

  28. Anis P, Eren HA. Comparison of alkaline scouring of cotton vs. alkaline pectinase preparation. AATCC Review. 2002;2:22–6.

    CAS  Google Scholar 

  29. Calafell M, Klung-Santner B, Guebitz G, Garria P. Dyeing behaviour of cotton fabric bioscoured with pectate lyase and polygalacturonase: a review. Color Tech. 2005;121:291–7.

    Article  CAS  Google Scholar 

  30. Calafell M, Garriga P. Effect of some process parameters in the enzymatic scouring of cotton using an acid pectinase. Enzym Microb Technol. 2004;34:326–31.

    Article  CAS  Google Scholar 

  31. Agrawal PB, Nierstrasz VA, Bouwhuis GH, Warmoeskerken MMCG. Cutinase and pectinase in cotton bioscouring: an innovative and fast bioscouring process. Biocatal and Biotransfor. 2008;26:412–21.

    Article  CAS  Google Scholar 

Download references

Acknowledgements

Manuscript proofreading by Dr. Philip James Shaw is appreciated.

Funding

This research was supported by the grant (P-13-50429) from the National Center for Genetic Engineering and Biotechnology, National Science and Technology Development Agency, Thailand.

Availability of data and materials

All the data generated or analyzed in this study are included in this article and its Additional file. The datasets used for the production of Figs. 2 and 3 could be found in the Additional file 1.

Authors’ contributions

DA and DC carried out plasmid construction, enzyme production and characterization. DA and KK participated in the high cell density fermentation. DA, PT, MN, BS, NN, and TN participated in enzymatic scouring experiment. AS, LE, TN, and VC conceived and designed of the study. DA, VC, TN and DC contributed to the analysis of the results and manuscript writing. All authors read and approved the final manuscript.

Competing interests

The authors declare that they have no competing interests.

Consent for publication

Not applicable.

Ethics approval and consent to participate

Not applicable.

Author information

Authors and Affiliations

Authors

Corresponding authors

Correspondence to Thidarat Nimchua or Duriya Chantasingh.

Additional file

Additional file 1:

Effect of pH on EndoPG activity. Effect of temperature on EndoPG activity. Effect of pH on stability of EndoPG activity. Effect of temperature (20–60 °C) on stability of EndoPG activity. RAW data of enzyme activities were calculated and showed as volumetric activity (U/ml) and % relative activity. Standard deviations (SD) were calculated from volumetric activity. (XLS 40 kb)

Rights and permissions

Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Abdulrachman, D., Thongkred, P., Kocharin, K. et al. Heterologous expression of Aspergillus aculeatus endo-polygalacturonase in Pichia pastoris by high cell density fermentation and its application in textile scouring. BMC Biotechnol 17, 15 (2017). https://doi.org/10.1186/s12896-017-0334-9

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/s12896-017-0334-9

Keywords